“Riding” the clutch is the most common reason for premature clutch failure. Even the slightest pressure on the pedal will partially disengage the clutch, causing the release bearing, pressure plate and flywheel to overheat.
The average lifespan of a clutch is anywhere between 20,000 to 150,000 miles. Luckily, your clutch will likely give you ample notice that something is going wrong. Don't get left at the side of the road with a vehicle that won't shift into gear. Read on to learn the signs and symptoms of a failing clutch.
Clutches tend to fail in one of two ways – either suddenly or gradually. With a sudden breakdown, the clutch ceases to work entirely and the car won't move. With gradual failure, you may experience problems such as the car not stopping when you press the pedal.
The most wear and tear done to a clutch is when the pedal is only half depressed. Do use the brake to hold yourself stationary on a hill, rather than the clutch. Do take off in first gear, rather than third. As a convenience, too many people will cut the engine in third and take off the following day the same.
If you “ride” the clutch, stepping too frequently on the pedal and repeatedly disengaging and reengaging the drivetrain, the friction can create enough heat to actually burn the clutch facings. This can ruin both the disk and the flywheel assembly. The most telling sign of a burnt clutch is the smell it gives off.
The clutch is one of the most important parts of your car – without it, you wouldn't be able to drive. Unfortunately, it is one of the most expensive pieces to repair.
The cost to repair a clutch can range between $500 to $2,500. It really depends on the car.
As a general rule, your car clutch will need to be replaced every 100,000 kilometres. However, you may need a clutch service or replacement more often depending on how you use your car.
Your clutch feels spongy, sticks or vibrates when you press it. You hear a squeaking or a grumbling noise when you press down on the pedal. You can rev the engine, but acceleration is poor. You have difficulty shifting gears.
Luckily, clutch failure is usually a slow process, showing signs over a long period rather than one day leaving you stranded without warning; however, clutch problems left unchecked will result in just that.
Leave your car in gear at a red light
As well as wearing out your leg muscles, you're also putting needless strain on the clutch. It's much better to put your car in neutral and apply the handbrake to keep it stationary. When you put your car in neutral, the clutch is spared unnecessary wear and tear.
Slipping the clutch for more pick-up
Slipping the clutch deliberately causes overheating and heavy damage to the clutch plates while making them unusable much before their expected life. In fact, doing so does not make your car accelerate faster but only slows you down.
If you are sure that your clutch has worn out beyond repair then you can potentially replace the clutch yourself at home. It is possible, but it is a relatively lengthy and complicated procedure. There are several fiddly steps where there is a wide scope for things to go wrong.
A clutch should last you between 50,000 and 100,000 miles before you need to replace it. When their lifespan comes to an end, it's vital to change your clutch as soon as possible as its vital to maintaining healthy performance of your vehicle.
The clutch in your vehicle is subject to constant friction, so it's no surprise that it may need a repair or replacement at some point. The deterioration of your clutch can be sped up through poor driving habits and with it being considered a 'wear and tear' item, it won't be covered by your warranty.
While braking, you should always depress the clutch.
This is one of the most common scenarios wherein people do apply the brakes but forget to disengage the clutch in-turn stalling the car. Well, stalling the car especially with transmission load will take a serious toll on your vehicle's gearbox assembly.
The trick is to let the clutch out to the engagement point quickly and then more slowly from there. The only way you can know where this engagement point is, is by getting a feel for the car.