The average lifespan of a clutch is anywhere between 20,000 to 150,000 miles. Luckily, your clutch will likely give you ample notice that something is going wrong. Don't get left at the side of the road with a vehicle that won't shift into gear.
The average cost for a Clutch Replacement is between $1,253 and $1,428. Labor costs are estimated between $584 and $737 while parts are priced between $669 and $691.
Replacing a clutch is a major job. Your mechanic will need to remove your car's drive shaft and transmission. This being the case, it makes sense to take any steps you can to save money.
Driving a car with a faulty clutch can cause further damage to your gearbox, starter motor or shifter. It is important to resolve any damage spotted with your clutch.
Sudden clutch failure can also be caused by problems with the pressure plates that squash the friction plate onto the flywheel. If the springs behind these plates fail, you might feel the clutch pedal go very heavy and then you'll lose drive.
The clutch should take a bit of pressure to move, and when you press down, you should be met with some resistance. If the clutch pedal feels 'spongey' or feels like you're pushing it into a block of warm butter, your clutch is likely going to need to be replaced soon.
Clutch Pedal Feels Loose or Spongey. Clutch Pedal is Hard to Engage. Transmission Makes A Grinding, Whirling or Chirping Noise in Neutral. Grinding Occurs When Shifting Gears.
A clutch should last you between 50,000 and 100,000 miles before you need to replace it. When their lifespan comes to an end, it's vital to change your clutch as soon as possible as its vital to maintaining healthy performance of your vehicle.
As a general rule, your car clutch will need to be replaced every 100,000 kilometres. However, you may need a clutch service or replacement more often depending on how you use your car. If it's almost time to get a clutch replacement, then you may notice that things aren't right with your car.
The most wear and tear done to a clutch is when the pedal is only half depressed. Do use the brake to hold yourself stationary on a hill, rather than the clutch. Do take off in first gear, rather than third. As a convenience, too many people will cut the engine in third and take off the following day the same.
Excessive engine revolutions
Excessively revving the engine while using clutch control, or keeping the clutch partially engaged while accelerating with the gas pedal, can cause unnecessary damage to the clutch.
There are two basic ways a clutch fails - it either fails to disengage, or fails to engage fully.
The time it takes to replace a clutch can vary depending on the type of vehicle you have, but it's generally between two and six hours. For many, this means you could take your car into the garage in the morning and get it back the very same day!
How many kms does a clutch last? Like most car parts there are few hard and fast rules, but consensus seems to be that a clutch should last for between 70,000km and 160,000km. A lot of that will depend on the type of driving you do and the loads you expect your vehicle to carry.
When performing a clutch replacement, it is best practice to replace the clutch disc, pressure plate, pilot bearing and throw out bearing. The flywheel is also resurfaced or replaced if it is beyond the service limit or if it is a dual mass flywheel (this type of flywheel is not machinable).
Waiting at traffic lights or junctions with the clutch down, first gear engaged and your foot on the brake can put unnecessary strain on the clutch. It is much better to change into neutral if you are going to be stopped for any length of time and to use the handbrake to keep the car stationary.
You can make it hours, days, or even weeks sometimes when your clutch just starts slipping. But if your car's clutch begins to slip when you're driving in higher gears – say, gear three and up – it's not long until it's going to leave you stranded.